Skytrak 6036 Service Manual Manuel d'utilisateur Page 10
- Page / 280
- Table des matières
- DEPANNAGE
- MARQUE LIVRES
Noté. / 5. Basé sur avis des utilisateurs
1-4
Model 6036 S\N 9B0499 and Before
Section 1. Safety Practices
Why
Ventilation
Radiator Cap
Soft Ground
Supports and
Straps
Oil Pressure
Pressure
Testing
Leaving Forklift
Parking
Wheels and
Tires
The safety precautions and practices in this manual
are extremely important. Not following them can
cause personal injury or death. Read this section
carefully and be sure you understand all the precau-
tions and practices noted before attempting to service
the forklift.
1.6 OPERATIONAL CONSIDERATIONS (cont.)
1.7 FINAL WORD
Item
What to do
Avoid prolonged running of the engine in
a closed area with inadequate ventilation.
Always turn the radiator cap slowly to the
first stop to relieve pressure.
Never work on a forklift on soft ground.
Check for additional ballast. Seek
assistance and install suitable supports if
necessary.
Make sure safe and stable supports or
straps are installed beneath or around a
component or structural member that may
fall before commencing work.
Before loosening hoses or tubes, turn off
the engine and operate the controls
several times to relieve pressure.
Make sure all test equipment is in good
condition.
Use only gauges specified.
Comply with test procedure specified.
Lower carriage to the ground.
Do not park or attempt to service forklift
on an incline. If unavoidable, block all
wheels.
Keep tires inflated to correct pressure.
Do not over-inflate tires.
Exhaust fumes are highly toxic and
can kill.
Escaping coolant can burn you seri-
ously.
To prevent serious injury and/or death.
To prevent serious injury and/or death.
A pressure explosion will cause
serious injury.
To prevent damage to the system or
the equipment, and to eliminate the
possibility of personal injury.
To prevent accidental injury.
To prevent serious injury and/or death.
To prevent dangerous travel and load
handling.
Over-inflation can cause tires to burst
and result in personal injury.
- Service Manual 1
- Effectivity Page 3
- SECTION CONTENTS 5
- Danger ! 7
- 1.3 PERSONAL CONSIDERATIONS 8
- 1.4 EQUIPMENT CONSIDERATIONS 8
- 1.5 GENERAL CONSIDERATIONS 9
- 1.7 FINAL WORD 10
- SECTION 2 12
- GENERAL INSTRUCTIONS 12
- 2.3 REPLACEMENT 13
- 2.4 HOSES AND TUBES 13
- 2.1 INTRODUCTION 13
- 2.2 CLEANING 13
- 2.7 TORQUES 14
- 2.5 BEARINGS 14
- 2.6 PRESSURE TESTING 14
- AND ADJUSTMENT 14
- 2.8 PAINTING 15
- 2.10 FLUID LEVELS AND 16
- LUBRICATION 16
- 2.9 AFTER SERVICE STARTUP 16
- AND CHECKS 16
- IMPORTANT: 17
- SECTION 3 19
- Section 3. Boom 20
- GOOSENECK 20
- OUTER BOOM 21
- 3.1.3 Outer Boom Replacement 23
- 3.1.4 Chain Replacement 27
- 3.1.5 Chain Lubrication 28
- 3.1.6 Chain Tension Check 28
- 3.1.8 Wear Pad Replacement 29
- 3.1.9 Hose Tensioning 30
- 3.3 QUICK ATTACH 33
- ASSEMBLY 33
- 3.4 TROUBLESHOOTING 34
- 3.5 SPECIFICATIONS 35
- SECTION 4 37
- OPERATOR'S CAB 37
- 4.2.2 Travel Select and 38
- Range Select Levers 38
- 4.2.3 Boom Control and Grille 40
- 4.3 MECHANICAL FOOT 41
- CONTROLS 41
- FUEL PUMP 43
- 4.4 REAR VIEW MIRRORS 44
- SECTION 5 46
- Tube within Tire 49
- Three Piece Wheel 50
- 5.1.2 Demounting Tire 50
- 5.1.11 Mounting Tire 53
- 5.1.12 Mounting Standard Tire 53
- 5.1.13 Mounting Optional Tire 54
- 5.2.6 Park Lock Unit 66
- 5.2.7 Carrier Assembly 68
- 5.4 SPECIFICATIONS 72
- 5.5 TROUBLESHOOTING 73
- SECTION 6 75
- DRIVE SHAFTS AND DROP BOX 75
- 6.2 DROP GEAR BOX 77
- 6.3 SPECIFICATIONS 78
- 7.2 HOW TO TOW 82
- THE FORKLIFT 82
- 7.3 HOW TO DRAIN 82
- TRANSMISSION 82
- Section 7. Transmission 83
- 7.9 TROUBLESHOOTING 84
- 7.10 SPECIFICATIONS 85
- 8.1 ENGINE PREVENTIVE 88
- MAINTENANCE 88
- 8.1.4 250 Hour Intervals 90
- 8.1.5 500 Hour Intervals 91
- 8.1.6 1,000 Hour Intervals 92
- 8.2 ENGINE COOLING SYSTEM 95
- 8.4.5 Fuel Lift Pump 99
- 8.4.6 Fuel Filter 100
- Section 8. Engine 101
- 8.4.7 Fuel Injection Pump 102
- Caution ! 103
- Warning ! 103
- 8.6 ENGINE REMOVAL 105
- 8.8 ENGINE INSTALLATION 107
- 8.7 ENGINE OVERHAUL 107
- 8.9 HEAD TORQUE CHECK 110
- 8.10 STEM TIP TO ROCKER 110
- ARM CLEARANCE 110
- 8.11 ENGINE STORAGE 111
- 8.12 TROUBLESHOOTING 112
- Example: 115
- 9.1.2 Boom Extend/Retract 118
- Section 9. Hydraulic System 121
- 9.1.4 Frame Tilt Circuit 124
- 9.1.5 Brake Circuits 127
- 9.1.6 Power Steering Circuit 130
- Refer to paragraph 9.2a 138
- S/N 8L0333 AND BEFORE 165
- Threadlocker 242 178
- IMPORTANT 179
- DO NOT operate any boom or 179
- 9.5 TROUBLESHOOTING 184
- 9.6 SPECIFICATIONS 191
- 9.6 SPECIFICATIONS (cont.) 192
- SECTION 10 194
- ELECTRICAL SYSTEM 194
- 10.2 WARNING DEVICES 196
- 10.2.2 Backup Alarm 197
- 10.4 CIRCUIT BREAKERS 198
- 10.3 WIRING HARNESSES 198
- Section 10. Electrical System 200
- Electrical System Circuits 202
- 10.5 STARTING CIRCUIT 203
- 10.5.3 Starter 208
- 10.5.4 Starting Motor Relay 213
- Weather Starting 214
- 10.6 CHARGING CIRCUIT 215
- Size of Battery 225
- Temperature 225
- State-of-Charge 225
- 10.7 SWITCHES 227
- AND SOLENOIDS 227
- OFF RUN THERMO START START 228
- Terminals 228
- 10.7.2 Neutral Start Switch 229
- 10.7.3 Fuel Run Solenoid 229
- 10.7.4 Park Lock Switch 230
- 10.7.6 Reverse Switch 233
- 10.7.7 Steering Select Switch 233
- 10.8 GAUGES AND INDICATOR 234
- 10.8.3 Hourmeter 235
- 10.8.4 Warning Lights 236
- 10.8.5 Engine 237
- Low Oil Pressure Sender 237
- 10.8.6 Engine Coolant 238
- High Temperature Sender 238
- 10.8.8 Transmission 238
- 10.8.9 Fuel Gauge 239
- Lighting System Circuits 242
- 10.9 OPTIONAL 243
- LIGHTING SYSTEM 243
- 10.9.2 Momentary Brake Light 245
- (Stop Light) 245
- 10.10 WINDSHIELD 246
- WASHER/WIPER 246
- Reservoir (Enclosed Cab Only) 247
- 10.12 CAB HEATER 252
- (ENCLOSED CAB ONLY) 252
- 10.11 FAN SWITCH AND FAN 252
- MOTOR (OPTIONAL) 252
- (Enclosed Cab Only) 254
- 10.13 EMERGENCY BRAKING 255
- AND STEERING SYSTEM 255
- Hydraulic Pump 256
- (S/N 7P0013 and Before) 256
- (S/N 7P0014 thru 9B0499) 257
- 10.14 TROUBLESHOOTING 258
- CONTENTS 258
- Important: Never jumper a 260
- IMPORTANT: Use only 265
- 10.15 SPECIFICATIONS 277
- JLG Worldwide Locations 280
Produits connexes et manuels pour Machines spéciales Skytrak 6036 Service Manual
(300 pages)
(176 pages)
(176 pages)© 2020, manymanuals.fr. Tous droits réservés | 0.147 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Commentaires sur ces manuels